Transportation Department, Federal Aviation Administration
The FAA proposes to adopt a new airworthiness directive (AD) for certain Pratt & Whitney Division (PW) Model PW4074D, PW4077D, PW4084D, PW4090, and PW4090-3 engines. This proposed AD was prompted by the discovery of a quality escape involving incorrect shot peening on certain high-pressure compressor (HPC) drum rotor disk assemblies. This proposed AD would require visually inspecting the HPC drum rotor disk assembly for incorrect shot peen coverage and, depending on the results of the inspection, replacing the HPC drum rotor disk assembly with a part eligible for installation. This proposed AD would also require removing and replacing certain HPC drum rotor disk assemblies before reaching certain life limits. The FAA is proposing this AD to address the unsafe condition on these products.
Document Headings Document headings vary by document type but may contain the following: the agency or agencies that issued and signed a document the number of the CFR title and the number of each part the document amends, proposes to amend, or is directly related to the agency docket number / agency internal file number the RIN which identifies each regulatory action listed in the Unified Agenda of Federal Regulatory and Deregulatory Actions See the Document Drafting Handbook for more details. Department of Transportation Federal Aviation Administration 14 CFR Part 39 [Docket No. FAA-2026-2724; Project Identifier AD-2025-01606-E] RIN 2120-AA64 AGENCY: Federal Aviation Administration (FAA), DOT. ACTION: Notice of proposed rulemaking (NPRM). SUMMARY: The FAA proposes to adopt a new airworthiness directive (AD) for certain Pratt & Whitney Division (PW) Model PW4074D, PW4077D, PW4084D, PW4090, and PW4090-3 engines. This proposed AD was prompted by the discovery of a quality escape involving incorrect shot peening on certain high-pressure compressor (HPC) drum rotor disk assemblies. This proposed AD would require visually inspecting the HPC drum rotor disk assembly for incorrect shot peen coverage and, ( printed page 13985) depending on the results of the inspection, replacing the HPC drum rotor disk assembly with a part eligible for installation. This proposed AD would also require removing and replacing certain HPC drum rotor disk assemblies before reaching certain life limits. The FAA is proposing this AD to address the unsafe condition on these products. DATES: The FAA must receive comments on this proposed AD by May 8, 2026. ADDRESSES: You may send comments, using the procedures found in 14 CFR 11.43 and 11.45 , by any of the following methods: Federal eRulemaking Portal: Go to regulations.gov . Follow the instructions for submitting comments. Fax: (202) 493-2251. Mail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room…
Citation: 91 FR 13984
